| |
Labor for Hyundai covered components is preformed by Factory-Trained Hyundai Techs
| Hyundai Engine Parts |
| • engine block & cylinder heads |
| • all internally lubricated parts including pistons, piston rings, pins & cylinder sleeves |
| • connecting rods, rod bearings, caps and bolts |
| • camshaft(s), camshaft bearings, buttons and plugs |
| • timing gears and timing chain or belt |
| • rocker arms, rocker arm pivots, shafts & bushings |
| • intake/exhaust valves, springs, guides, adjusters, retainers & seats |
| • pushrods and lifters |
| • intake manifold |
| • exhaust manifolds |
| • balance shaft |
| • water pump, fuel pump, thermostat |
| • oil pump, cover, gears, pressure relief valve & screen |
| • rotor housing, rotors, shims & silent shaft |
| • all internal fasteners, nuts & bolts |
| • turbocharger/supercharger assembly including boost valve & wastegate |
| • seals and gaskets |
| • crankshaft, pulley, main bearings, caps and bolts |
| • oil pan |
| • valve, timing and side covers |
| • thermostat housing |
| • water pump pulley |
| • engine mounts |
| • harmonic balancer |
| • flex plate/flywheel & ring gear |
| Hyundai Transmission & Transaxle |
| • transmission/transaxle case |
| • all internally lubricated parts including ring & pinion gears |
| • oil pump, cover, gears, housing and vanes |
| • torque converter & valve body(s) |
| • throttle valve & valve pack |
| • governor, gear and cover |
| • parking gear and pawl |
| • sprags, sprockets, chain & springs |
| • stator and shaft |
| • pressure regulator valve & pressure switches |
| • solenoids |
| • automatic transmission/transaxle clutch, drums, pistons & steel plates |
| • servos and rings & planetary and sun gears |
| • blockers, synchronizer hubs and keys |
| • bearings, bushings & bands |
| • supports and shafts |
| • control rings & extension housing |
| • speedometer drive gears |
| • adjusters, accumulators and rings |
| • all internal fasteners, nuts and bolts |
| • shift cover and forks |
| • separate bell housing |
| • transfer case & all internal parts within the transfer case |
| • seals and gaskets |
| • (STANDARD TRANSMISSION CLUTCH ASSEMBLIES & ALL COMPONENT PARTS ARE NOT COVERED) |
| • Oil pan |
| • detent cable |
| • kickdown link |
| • TVI/throttle cable |
| • vacuum modulator |
| • transmission mounts |
| • differential/axle housing(s) |
| • all internally lubricated parts including the axle flange |
| • ring and pinion gear/carrier assembly |
| • spider gears and bearings |
| • cover, pins & retainers |
| • positraction clutches, plates and springs |
| • seals and gaskets |
| • constant velocity joints |
| • slip joint |
| • front wheel drive axles/half-shafts & wheel bearings |
| • u-joints & couplings |
| • flex disc & prop shaft |
| • center support bearings |
| Hyundai Steering Parts |
| • steering gear housing |
| • internal parts including control rings, valves, pinion/pitman/sector shaft & gear, bearings, adjusters |
| • rack and pinion housing |
| • internal parts including control valve, rack bellows, mounts, rack shaft & yoke, spool valve, bearings |
| • power steering pump |
| • internal parts including housing, reservoir, shaft & vanes |
| • power steering pump mounting brackets |
| • seals and gaskets |
| • Tierod, idler & pitman arms, center/drag link, coupling & shafts |
| • cooler lines |
| • Steering wheel tilt & telescoping mechanism |
| • master cylinder |
| • vacuum or hydraulic brake booster assembly |
| • hydraulic lines, hoses and fittings |
| • brake pedal apply pin |
| • seals and gaskets |
| • compensator/proportioning valve |
| • metering valve |
| • calipers, piston, seal and dust boot |
| • wheel cylinders, cups, seals, spring |
| • backing plate & brake adjusters |
| • brake pedal, pedal lever & pedal pivot |
| • parking brake cable |
| • ABS component parts |
| • including control processor/module, speed sensor, solenoid, accumulator & pressure diff. switch |
| • condensor |
| • compressor |
| • evaporator |
| • orifice/expansion |
| • seals and gaskets |
| • accumulator |
| • receiver drier |
| • automatic temperature control programmer |
| • clutch assembly including coil, disc & pulley |
| • control cables |
| • cutoff switch |
| • serpentine belt tensioner, bearing & pulley |
| • compressor mounting brackets |
| • idler pulley and bearings |
| • air conditioning/heater blower motor |
| Hyundai Front & Rear Suspension |
| • upper and lower control arms, shafts and bushings |
| • struts, housing and cartridge |
| • spindle/steering knuckle and spindle support |
| • wheel bearings |
| • ball joints and bushings |
| • kingpin and bushings |
| • stabilizer bar, torsion bar, mounts |
| • Coil & leaf springs, seats & bushings, leaf spring shackles |
| • electronic level control components |
| • including pump, accumulator, lines & bags |
| • Upper/lower control arms, shafts & bushings |
| • upper/lower ball joints |
| • struts, housing & cartridge |
| • alternator housing |
| • all internal parts including bearings, bushings, brushes, rectifier bridge, diodes, field coil & rotor |
| • alternator mounting bracket |
| • voltage regulator |
| • starter motor housing |
| • all internal parts including bushings, brushes, field windings, starter drive & solenoid |
| • front & rear wiper motor, transmission & linkage |
| • power window motor |
| • window regulators |
| • power seat motor |
| • steer column switches for signal, headlamp, dimmer, wiper, washer & speed control |
| • mirror motor switch |
| • brake light switch |
| • neutral safety switch |
| • glove box light switch |
| • courtesy light switch |
| • cooling fan relay |
| • air control solenoid |
| • air regulator valve |
| • I.A.C. motor |
| • electronic ignition module |
| • ignition coil |
| • engine distributor including shaft, gear, bushing & module |
| • throttle position sensor |
| • vehicle speed sensor & M.A.P. sensor |
| • knock sensor & barometric pressure sensor |
| • cruise control module, servo, cables & switches |
| • instrument cluster including speedometer/odometer/tachometer, all gauges |
| • burglar alarm or electronic entry systems |
| • including remote entry receiver, sender & module |
| • door lock actuators |
| • mirror motor |
| • power window switch & power lock switch |
| • rear window defogger |
| • horn and relay |
| • convertible top motor & sunroof motor |
| • power antenna motor & headlamp motor |
| • power trunk/hatch release motor, switch & solenoid |
| • power sliding door motor & switch |
| • electronic control modules |
| • including electronic control unit, PT control module, trans control module |
| • electronic throttle control module |
| • crank angle sensor |
| • camshaft position sensor & throttle position motor |
| • fuel pulse dampener |
| • wide open throttle switch |
| • thermo time switch & fuel pump relay |
| • automatic temperature control sensor |
| • ride height sensor & relay |
| • oxygen (02) sensor & mass air flow sensor |
| • manifold differential pressure sensor |
| • coolant temperature sensor |
| • OEM radio/graphic equalizer/compact disc player |
| Hyundai Cooling System & Fuel System |
| • radiator, mounting brackets & coolant recovery tank |
| • fan clutch, fan blades and motor |
| • fan shroud |
| • heater core |
| • transmission cooler |
| • fuel lines & fuel tank |
| • fuel pressure regulator |
| • level sending unit |
| • fuel injectors and seals |
| • injection pump |
| • ESC systems |
| • fuel injection control components |
| • including mixture processor, throttle body assembly, cutoff valve |
| • fuel rail, fuel distributor, trigger contacts |
| • cold start valve, fuel injection valve, fuel accumulator |
| • tank filler neck and o-ring |
|
|
|
While every effort has been made to provide a complete listing for your Hyundai. This list is intended to assist the visitor with decisions. Refer to Hyundai's brochure and contract for most recent component information. Limitations and exclusions may apply. |
